許多主動擋車主，剛買新車時保護有加。但一過保修期，關于如何對車輛查看、保養、修理，懶得搞清楚：“車子能開則開，動不了再修。”
Many active car owners are protected when they buy a new car. But after the warranty period, about how to inspect, maintain and repair the vehicle, I am too lazy to make it clear: "If the car can drive, it can not be repaired."
當發生事端送車去修理時，由于沒有及時修理保養，以致主動變速器的小故障擴大、惡化而導致大事端。
When an accident happens and the vehicle is sent to repair, the minor fault of the active transmission is enlarged and worsened due to the lack of timely repair and maintenance.
那怎樣對主動擋車型進行保養呢?
So how to maintain the active gear?
1.要經常查看主動變速箱油液位是否正常。主動變速箱油的查看方法與發動機機油不一樣，發動機機油在冷車狀態下查看、而變速箱油是需要將油預熱到50℃左右，再將擋位桿在各擋位停留2秒鐘后置于泊車擋，此時油尺正常油面應位于較高與較低線之間，如不夠，應及時添加相同質量的油品。
1. Always check whether the oil level of the active gearbox is normal. The inspection method of active transmission oil is different from that of engine oil. The engine oil is viewed in the cold state, and the transmission oil needs to be preheated to about 50 C. Then the gear rod is placed in the parking gear after staying in each gear for 2 seconds. At this time, the normal oil level of the oil gauge should be between the highest and lowest lines. If not enough, the same quality oil should be added in time.
2.把握好替換主動變速箱油的周期。主動變速箱內部控制組織非常精細，配合空隙小，所以大部分廠家主張主動變速箱換油周期一般為兩年或4~6萬公里。在正常運用的過程中，變速箱油的工作溫度一般在120攝氏度左右，因此對油品的質量要求很高，還必須保持清潔。
2. Grasp the cycle of replacing active transmission oil. Active transmission internal control organization is very fine, with small space, so most manufacturers advocate that the oil change cycle of active transmission is generally two years or 40-60,000 km. In the normal operation process, the working temperature of transmission oil is generally about 120 degrees Celsius, so the quality of oil is very high, and it must be kept clean.
其次，變速箱油運用時間長了以后會發生油垢，有可能會形成油泥，會加大各摩擦片和各部件的磨損，并且還影響系統油壓，使動力傳遞受到影響。第三，臟油中的油泥會使各閥體中閥體的移動不暢，油壓控制受影響，從而使主動變速箱出現異常。
Secondly, oil scale will occur after the transmission oil is used for a long time, which may form sludge, increase the wear of friction plates and components, and also affect the oil pressure of the system, so that power transmission is affected. Thirdly, the sludge in dirty oil will make the movement of the valve body in each valve body not smooth, and the oil pressure control will be affected, so that the active transmission will be abnormal.
3.正確地替換變速箱油。目前較好的換油方法是動態換油，采用專用的變速箱清洗設備，在變速箱運轉的過程中，將舊油充分循環，排放干凈后再參加新的變速箱油，從而使換油率高達90以上，保證杰出的換油效果。
3. Correctly replace transmission oil. At present, the better way to change oil is to change oil dynamically. Special gearbox cleaning equipment is used. During the operation of gearbox, the old oil is fully recycled and discharged clean, then new gearbox oil is added, so that the oil exchange rate can reach more than 90 and the excellent oil exchange effect can be guaranteed.
車主應培養主動查看、維護、保養的意識，可以學習一些維護、保養車輛的基本知識，認真閱覽隨車運用說明，記住一些必要數據等?？茖W(xué)養車，才能保證車輛處于杰出的技術狀態，保證行車安全。
Car owners should cultivate the awareness of active inspection, maintenance and maintenance. They can learn some basic knowledge of vehicle maintenance and maintenance, read the instructions carefully, and remember some necessary data. Scientific vehicle maintenance can ensure that the vehicle is in an outstanding technical state and safe driving.
The above information is our Jinan automatic transmission maintenance and distribution hope to help you all on our website: http://qiubet3724.com!
